What's your latest food project? Tell us about it
TELL US

Smoked Sea Salt Recipe

Smoked Sea Salt
Difficulty: Easy | Total Time: 1 hr 30 mins | Active Time: | Makes: 1/3 cup

By smoking salt, you can give food a smoky flavor without doing any actual smoking. It’s pure smoke in a jar.

Game plan: This recipe makes 1/3 cup smoked sea salt, but you can smoke larger quantities. Just use a larger pan and make sure the salt sits in a thin layer in the pan.

Special equipment: We recommend using a charcoal grill or a smoker for this recipe. You will also need long heatproof tongs, matches or a lighter, newspaper, 2 buckets of water (one to soak the wood chips and the other to refill the aluminum loaf pan), 2 oven mitts, 1 disposable aluminum 9-by-5-inch loaf pan, 1 disposable aluminum 8-inch square pan, and an oven thermometer.

A chimney starter, which looks like a large beer stein, is handy for lighting charcoal. They can be purchased at hardware stores or online.

Lump charcoal is preferred because the charred pieces of wood burn hotter and cleaner than briquettes, the uniform black pillows made from carbonized wood and a starchy binder. If you do buy briquettes, avoid the self-lighting ones, which are laden with chemicals.

Buy pure, resin-free, bark-free wood chips. Choose your wood chips based on the origin of the ingredient you are smoking. For example, use cedar chips for Pacific salmon and hickory chips for Southern catfish. For this recipe, we recommend hickory chips, but any wood will do. Wood chips can... read more

INGREDIENTS
  • 1/3 cup coarse sea salt
  • 2 cups hickory wood chips
  • 8 quarts lump charcoal, plus more as needed
INSTRUCTIONS
  1. Using a sharp knife, punch holes in the bottom of the square aluminum pan. Add salt and spread in an even layer.
  2. Soak the wood chips in a bucket of water for at least 15 minutes.
  3. Prepare the grill: Remove the cooking grate and set it aside. Fill a chimney starter three-quarters of the way with charcoal, then pour the unlit charcoal onto one side of the charcoal grate. Using tongs, stack the charcoal in a slight slope against the side of the grill bowl. Remove 1 cup of the wood chips from the water, shaking off any excess, and lay the damp chips in the middle of the unlit charcoal. Fill the chimney again halfway with charcoal. Place the chimney on the charcoal grate next to the unlit coals. Twist two or three sheets of newspaper, form the twisted paper into rings, and place them under and inside the chimney. Light the newspaper through the holes at the bottom of the chimney. After about 5 minutes, the charcoal should be red and flames should have appeared toward the top of the chimney.
  4. Carefully pour the lit charcoal onto the pile of unlit charcoal on the grate. Use tongs to stack the lit coals on the pile. Top the lit charcoal with the remaining 1 cup drained, damp wood chips. Set the empty chimney aside. Place the cooking grate back on the grill. Fill the 9-by-5-inch aluminum loaf pan three-quarters of the way with cold water and place it on the cooking grate over the hot charcoal (the cold water is needed to keep the grill temperature low). Set an oven thermometer in one of the grill lid’s vent holes or on the cooking grate near the edge of the grill and opposite the charcoal. Cover the grill, making sure that the bottom and top vents are open and that smoke is coming out of the vents. (If smoke is not coming out, check your fire to make sure it is lit. If it’s not, relight it, using tongs to transfer the warm charcoal from the grill back into the chimney starter.) Let the grill heat until it reaches at least 250°F, about 15 minutes.
  5. Place the aluminum pan of salt on the cooking grate but not over the flaming charcoal. Cook, covered, making sure the grill lid’s vent is over the salt (not the fire), until the salt has darkened, about 1 hour. Shake the pan of salt halfway through the cooking time. Also, occasionally check the grill temperature. It should be between 250°F and 300°F. If it is too hot, add more water to the loaf pan (it evaporates) and close the lower vent by half. If the temperature is too low, make sure the bottom and top vents are open, or you may need to feed your charcoal by lighting more in the chimney. When the salt is done, let it cool completely before storing it in a glass container.